Ford F150 Engine Diagram Pdf

• Contents
• Table of Contents
• Bookmarks

  Also See for Ford F150

  Related Manuals for Ford F150

  Summary of Contents for Ford F150

• Page 1 Manual heating and air conditioning Electronic automatic temperature control Rear window defroster Lights Headlamps Turn signal control Bulb replacement Driver Controls Windshield wiper/washer control Steering wheel adjustment Power windows Mirrors Speed control Message center Tailgate 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 2: Table Of Contents

  Recreational towing Roadside Emergencies Getting roadside assistance Hazard flasher switch Fuel pump shut-off switch Fuses and relays Changing tires Jump starting Wrecker towing Customer Assistance Reporting safety defects (U.S. only) Cleaning 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 3: Table Of Contents

  Ford Motor Company. Ford may change the contents without notice and without incurring obligation. Copyright © 2004 Ford Motor Company...

• Page 4: Introduction

  State of California to cause cancer and birth defects or other reproductive harm. CONGRATULATIONS Congratulations on acquiring your new Ford. Please take the time to get well acquainted with your vehicle by reading this handbook. The more you know and understand about your vehicle, the greater the safety and pleasure you will derive from driving it.
• Page 5 Emissions Defect and Emissions Performance Warranties. For a detailed description of what is covered and what is not covered, refer to the Warranty Guide that is provided to you along with your Owner's Guide. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 6 • where the driver was positioning the steering wheel. To access this information, special equipment must be directly connected to the recording modules. Ford Motor Company and Ford of Canada do not access event data recorder information without obtaining consent,...
• Page 7 Driving chapter. F150 SuperCrew Owners: Snowplowing Your vehicle is not recommended for snowplowing. Ford makes no representation as to the suitability of your vehicle for snowplowing, in particular regarding the potential for exceeding vehicle weight limits, airbag (SRS) deployment sensitivity, vehicle crash integrity, or powertrain durability.
• Page 8 Brake Fluid - Anti-Lock Brake System Non-Petroleum Based Traction Control AdvanceTrac Master Lighting Switch Hazard Warning Flasher Fog Lamps-Front Fuse Compartment Fuel Pump Reset Windshield Wash/Wipe Windshield Rear Window Defrost/Demist Defrost/Demist 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 9 Battery Acid or Sparks Explosive Gas Fan Warning Maintain Correct Fluid Power Steering Fluid Level Emission System Engine Air Filter Passenger Compartment Jack Air Filter Check fuel cap Low tire warning 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 10: Instrument Cluster

  Instrument Cluster Instrument Cluster WARNING LIGHTS AND CHIMES Base instrument cluster Base with Tachometer instrument cluster Mid instrument cluster 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 11 Electronic throttle control (if equipped): Illuminates when the engine has defaulted to a 'limp-home' operation. Report the fault to a dealer at the earliest opportunity. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 12 Safety belt: Reminds you to fasten your safety belt. A chime will also sound to remind you to fasten your safety belt. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 13 If the indicators stay on or flash faster, check for a burned out bulb. High beams: Illuminates when the high beam headlamps are turned on. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 14 Headlamps on warning chime: Sounds when the headlamps or parking lamps are on, the ignition is off (the key is not in the ignition) and the driver's door is opened. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 15: Gauges

  Never remove the coolant reservoir cap while the engine is running or hot. Odometer: Registers the total miles (kilometers) of the vehicle. • With Mini Message Center 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 16 Engine oil pressure gauge: Indicates engine oil pressure. The needle should stay in the normal operating range (between "L" and "H"). If the needle falls below the normal range, stop the vehicle, turn 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 17 For more information, refer to Filling the tank under the Fuel Information section in the Maintenance and Specifications chapter. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 18: Entertainment Systems

  Entertainment Systems Entertainment Systems FORD AM/FM STEREO SYSTEM (IF EQUIPPED) Tune: Press to manually go up or down the radio frequency. Also use in menu mode to select various settings. 2. Audio: Press to access select various settings. Treble: Press to adjust the treble setting. Use...
• Page 19 "nominal" listening level when the ignition switch is turned back on. 7. CLK (Clock): Press CLK to toggle between displaying the radio frequency and the clock setting. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 20 Entertainment Systems FORD SINGLE CD SOUND SYSTEM (IF EQUIPPED) Tune: Press to manually go up or down the radio frequency. Also use in menu mode to select various settings. 2. Phone/mute: Press to mute the playing media. Press again to return to the playing media.
• Page 21 CD. 8. Compress (Compression): In CD mode, brings soft and loud CD passages together for a more consistent listening level. 9. Repeat: Press to repeat the current CD track. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 22 CD is already loaded into the system, CD play will begin where it ended last. 18. CD eject: Press to eject a CD. 19. CD slot: Insert a CD label side 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 23 Entertainment Systems FORD DUAL MEDIA SOUND SYSTEM (IF EQUIPPED) Tune: Press to manually go up or down the radio frequency. Also use in menu mode to select various settings. 2. Seek: Press to access the next strong station or track.
• Page 24 8. Shuffle: Press to play CD tracks in random order on the selected CD. 9. Compress (Compression): In CD mode, brings soft and loud CD passages together for a more consistent listening level. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 25 CD is already loaded into the system, CD play will begin where it ended last. 19. CD eject: Press to eject a CD. 20. CD slot: Insert a CD label side 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 26 22. Scan: Press for a brief sampling of radio stations or CD tracks. Press again to stop. FORD PREMIUM/AUDIOPHILE IN-DASH SIX CD SOUND SYSTEM (IF EQUIPPED) Tune/Disc selector: Press to manually go up or down the radio frequency or to select a desired disc.
• Page 27 RDS-equipped stations for a certain category of music format: Classic, Country, Info, Jazz, Oldies, R&B, Religious, Rock, Soft, Top 40. RDS (only available in FM mode) must be activated to access the Traffic, Find and Show functions. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 28 CD. 8. Compress (Compression): In CD mode, brings soft and loud CD passages together for a more consistent listening level. 9. Repeat: Press to repeat the current CD track. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 29 18. LOAD: Press to load a CD. Press and hold to autoload up to six CDs. 19. CD eject: Press to eject a CD. Press and hold to auto eject all CDs present in the system. 20. CD slot: Insert a CD label side 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 30 10–12 hours of play to maintain good sound/operation. Don't: • Expose tapes to direct sunlight, extreme humidity, heat or cold. • Leave tapes in the cassette player for a long time when not being played. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 31 Due to technical incompatibility, certain recordable and re-recordable compact discs may not function correctly when used in Ford CD players. Irregular shaped CDs, CDs with a scratch protection film attached, and CDs with homemade paper (adhesive) labels should not be inserted into the CD player.

• Page 32: Climate Controls

  • Remove any snow, ice or leaves from the air intake area at the base of the windshield. To aid in side window defogging/demisting in cold weather: 1. Select 2. Adjust the temperature control to maintain comfort. 3. Set the fan speed to the highest setting. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 33: Manual Heating And Air Conditioning

  : Distributes air through the windshield defroster vents and floor vents. : Distributes outside air through the windshield defroster vents. 3. Rear defrost (if equipped): Press to defrost the rear window. Refer to Rear Window Defrost for more information. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 34 ) and panel/floor ( ) modes: • Move the temperature control to the coolest setting. • Select A/C and recirculated air ( ). Use recirculated air with A/C to provide colder airflow. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 35 Do not place objects on top of the instrument panel as these objects may become projectiles in a collision or sudden stop. AUTOMATIC TEMPERATURE CONTROL (ATC) SYSTEM (IF EQUIPPED) 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 36 Recirculation control: Press to activate/deactivate air recirculation in cabin. Recirculated air may reduce the amount of time to cool down the interior of the vehicle and may also help reduce undesired 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 37 The system will automatically determine fan speed, airflow location, A/C on or off, and outside or recirculated air, to heat or cool the vehicle to reach the desired temperature. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 38 If your vehicle is equipped with a full message center, refer to Units (Fahrenheit/Celsius) in the Driver Controls chapter. If your vehicle is equipped with a mini message center, refer to Mini message center electronic compass temperature display in the Driver Controls Chapter. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 39 Recirculation can be engaged manually in any other airflow selection except (defrost). Recirculation may turn off automatically in all airflow selections except MAX A/C. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 40 • Select A/C and recirculated air ( ). Use recirculated air with A/C to provide colder airflow. • Set the fan to the highest speed initially, then adjust to maintain comfort. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 41: Rear Window Defroster

  This may cause damage to the heated grid lines and will not be covered by your warranty. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 42: Lights

  6. Deselect the autolamps after the desired autolamp delay time (maximum of 3 minutes) At this point, the headlamps and park lamps will turn off. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 43 Failure to activate your headlamps under these conditions may result in a collision. High beams Push the lever toward the instrument panel to activate. Pull the lever towards you to deactivate. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 44 1. Park the vehicle directly in front of a wall or screen on a level surface, approximately 25 feet (7.6 meters) away. • (1) Eight feet • (2) Center height of lamp to ground • (3) Twenty-five feet 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 45 6. HORIZONTAL AIM IS NOT REQUIRED FOR THIS VEHICLE AND IS NON-ADJUSTABLE. 7. Repeat step 3–5 for the other headlamp. 8. Close the hood and turn off the lamps. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 46: Turn Signal Control

  The rear dome lamp can be turned ON (center) or OFF (right) by sliding the control. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 47 With the ignition key in the ACC or ON position, the rear dome lamp can be turned ON or OFF by sliding the control. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 48: Bulb Replacement

  Exterior mounted mirror turn See your dealer signal indicator (if equipped) All replacement bulbs are clear in color except where noted. To replace all instrument panel lights - see your dealer 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 49 Grasp the bulb only by its plastic base and do not touch the glass. The oil from your hand could cause the bulb to break the next time the headlamps are operated. Install the new bulb in reverse order. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 50 1. Make sure the headlamp control is in the OFF position. 2. Open the tailgate to expose the lamp assembly screws and remove the two screws from the tail lamp assembly. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 51 OFF position. 2. Remove the bulb socket from the foglamp by turning counterclockwise. 3. Disconnect the electrical connector from the foglamp bulb. Install the new bulb in reverse order. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 52 3. Pull out the old bulb from the socket and push in the new bulb. 4. Install the bulb socket in lamp assembly by turning it clockwise. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 53: Driver Controls

  2. Attach the new wiper to the wiper arm and press it into place until a click is heard. 3. Replace wiper blades every 6 months for optimum performance. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 54 The appearance of your vehicle's overhead console will vary according to your option package. If your vehicle is equipped with a overhead console rail system, there are several features that can operated. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 55 • Failure to pin the bins together can allow the bins to become separated from the rail under certain conditions. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 56 Place both palms on the underside of the storage bin, avoiding the storage bin door. Push upwards with palms. While pushing upwards with palms, grip the side latches with fingers and squeeze. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 57 15A fuse should supply a maximum of 180 Watts and a 10A fuse should supply a maximum of 120 Watts. Exceeding these limits will result in a blown fuse. Always keep the power point caps closed when not being used. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 58 Mobile Communication Equipment includes, but is not limited to cellular phones, pagers, portable email devices, in vehicle communications systems, telematics devices and portable two-way radios. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 59: Power Windows

  Allows the driver's window to open fully without holding the control down. Press completely down on the bottom part of the rocker switch and release quickly. Press the top part of the rocker switch to stop. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 60: Mirrors

  MIRRORS Automatic dimming rear view mirrors (if equipped) Your vehicle is equipped with an inside rear view mirror with an auto-dimming function. The electronic day/night mirror will change from 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 61 Heated mirrors remove ice, mist and fog. To activate the heated mirrors, press the rear defrost button located on the climate control panel. Refer to Rear Window Defrost in the Climate Controls chapter for more information. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 62 • Press the bottom of the control to adjust the pedals toward you. • Press the top of the control to adjust the pedals away from you. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 63: Speed Control

  • If the vehicle speed decreases more than 10 mph (16 km/h) below your set speed on an uphill, your speed control will disengage. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 64 You can also use the CST control to operate the Tap-Down function. Press and release this control to decrease the vehicle set speed in small amounts by 1 mph (1.6 km/h). 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 65 In AM, FM1, or FM2 mode: • Press MEM to select preset stations within the selected radio band. In CD mode: • Press MEM to select the next selection on the CD. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 66 Note: The moon roof will open to the "comfort" position first before opening all the way. The "comfort" position helps to alleviate rumbling wind noise which may happen in the vehicle with the roof fully opened. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 67 Do not use the HomeLink Wireless Control System with any garage door opener that lacks safety stop and reverse features as required by 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 68 Some entry gates and garage door openers may require you to replace step 3 with procedures noted in the "Gate Operator and Canadian Programming" in this section for Canadian residents. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 69 3 with the following: Note: If programming a garage door opener or gate operator, it is advised to unplug the device during the "cycling" process to prevent overheating. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 70 Reprogramming a single HomeLink button To program a device to HomeLink using a HomeLink button previously trained, follow these steps: 1. Press and hold the desired HomeLink button. Do NOT release the button. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 71: Message Center

  This control displays the following control displays: • Odometer/Compass • Trip odometer/Odometer/Compass • Distance to Empty • Average Fuel Economy • Trip Elapsed Drive Time Odometer/Trip odometer Refer to Gauges in the Instrument Cluster chapter. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 72 The range of zone values are from 01 to 15 and "wraps" back to 01. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 73 500 miles (800 km). This value is not the same as the average fuel economy display. The running average fuel economy is reinitialized to a factory default value if the battery is disconnected. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 74 1. Press and release RESET in order to start the timer. 2. Press and release RESET to pause the timer. 3. Press and hold RESET for 2 seconds in order to reset the timer. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 75 2. Press the RESET control to change from English to Metric. Autolocks This feature automatically locks all vehicle doors when the vehicle is shifted into any gear, putting the vehicle in motion. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 76 3. Press and hold the RESET control to set the language choice. System warnings System warnings alert you to possible problems or malfunctions in your vehicle's operating systems. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 77 REDUCED ENGINE POWER. Displayed when the engine is overheating. Stop the vehicle as soon as safely possible, turn off the engine. If the warning stays on or continues to come on, contact your dealer as soon as possible. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 78 DATA ERR. These messages indicate improper operation of the vehicle network communication between electronic modules. • Fuel computer • Charging system • Autolamp delay • Auto locks • Brake fluid • Compass • Outside temperature • Engine sensor 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 79 This variation is four degrees between adjacent zones and will become noticeable as the vehicle crosses multiple zones. A correct zone setting will eliminate this error. Refer to Compass zone adjustment. Compass zone adjustment 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 80 3. Drive the vehicle slowly (less than 3 mph [5 km/h]) in circles until CAL indicator turns off. As many as 5 complete circles may be required. 4. The compass is now calibrated. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 81: Tailgate

  6. Lift tailgate to a 80 degree angle from horizontal. 7. Remove tailgate from left side hinge by sliding tailgate to the right. To install, follow the removal procedures in reverse order. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 82 The bed extender should always be kept in the stowed position with the tailgate closed when not in use. When driving the vehicle off road, the bed extender should be removed and the tailgate closed. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 83 Note: Remove and store the bed extender when not in use. To install the bed extender, follow the removal procedure in reverse order. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 84: Locks And Security

  • Pressing the manual lock button on the door. • Operating the remote entry transmitter. • Operating the keyless entry keypad. • Operating the driver's door with a key. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 85 33 feet (10 meters). A decrease in operating range could be caused by: • weather conditions, • nearby radio towers, • structures around the vehicle, or • other vehicles parked next to your vehicle. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 86 • 20 seconds elapse after all vehicle doors are closed and locked using the remote entry transmitter, the keyless entry pad, or the power door lock control (while the accompanying door is open). 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 87 Press again or turn the ignition to 2 (ACCESSORY) or 3 (ON) to deactivate. Note: The panic alarm will only operate when the ignition is in the 1 (OFF/LOCK) position. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 88 3. Repeat this procedure for another remote transmitter if desired. Replacing the battery The remote entry transmitter uses one coin type three-volt lithium battery CR2032 or equivalent. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 89 • Take all your vehicle's transmitters to your dealer for programming, or • Perform the programming procedure yourself. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 90 The illuminated entry system will turn off the interior lights if: • the ignition switch is turned to the 3 (ON) position, or • the remote transmitter lock control is pressed, or • after 25 seconds of illumination. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 91 3. Turn the ignition to the 3 (ON) position, and within five seconds, press the control two times. Note: After turning the ignition to the 3 (ON) position, two horn chirps should be heard, indicating that the 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 92 Before following the activation or deactivation procedures, make sure the ignition is off, and all vehicle doors are closed. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 93 6. Release the 7 • 8. The user should receive a horn chirp to indicate the system has been disabled or a chirp followed by a honk to indicate the system has been enabled. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 94 1. Enter the factory set 5–digit code. 2. Press and release 1 • 2 then, 3. Press and hold the 1 • 2 for two seconds. This must be done within five seconds of completing Step 1. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 95: Anti-Theft System

  The dealer can program your spare keys to your vehicle or you can program the keys yourself. Refer to Programming spare keys for instructions on how to program the coded key. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 96 Note: The SecuriLock passive anti-theft system is not compatible with non-Ford aftermarket remote start systems. Use of these systems may result in vehicle starting problems and a loss of security protection. Note: Large metallic objects, electronic devices that are used to purchase gasoline or similar items, or a second coded key on the same key chain may cause vehicle starting issues.
• Page 97 5. Within 10 seconds of removing the second coded key, insert the new unprogrammed key (new key/valet key) into the ignition and turn the 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 98 Steps 1 through 5. If failure repeats, bring your vehicle to your dealership to have the new spare key(s) programmed. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 99: Seating And Safety Restraints

  Adjust your head restraint so that it is located directly or as close as possible behind your head. The head restraints can be moved up and down. Push control to lower head restraint. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 100 Using the armrest (if equipped) Push the release control to move the armrest up or down. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 101 The control is located on the outboard side of the seat cushion. Press the front or rear portion to tilt the seat. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 102 • Push control again to set at low heat. • Push again to deactivate. The indicator light on the control will illuminate when activated. The system automatically shuts off after 10 minutes. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 103 Push control to lower head restraint. Folding up the rear seats (if equipped ) The rear seat has a split 60/40 cushion. Each seat cushion can be flipped up into the seatback position. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 104: Safety Restraints

  • Driver's seat position sensor. • Front crash severity sensor. • Front passenger sensing system • Passenger Air Bag Off indicator light. • Passenger air bag ON/OFF switch (if equipped) 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 105 This allows your Personal Safety System to distinguish between different levels of crash severity and modify the deployment strategy of the dual-stage air bags and safety belt pretensioners. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 106 "pass air bag off" indicator will light and stay lit to remind you that the front passenger frontal air bag is off. See Front passenger sensing system in the airbags section of this chapter. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 107 • The warning light will either flash or stay lit. • The warning light will not illuminate immediately after ignition is turned on. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 108 Never wear the shoulder belt under the arm. 2) Never swing the safety belt around your neck over the inside shoulder. 3) Never use a single belt for more than one person. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 109 Make sure the tongue is securely fastened in the buckle. • Front seats • Rear seats (if equipped) 2. To unfasten, push the release button and remove the tongue from the buckle. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 110 5 mph (8 km/h) or more, the combination safety belts will lock to help reduce forward movement of the driver and passengers. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 111 Restraints for Children or Safety Seats for Children later in this chapter. How to use the automatic locking mode 1. Buckle the combination lap and shoulder belt. • Front passenger seat • Rear seats (if equipped) 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 112 Your vehicle is equipped with safety belt buckle pretensioners at the driver and front outboard passenger seating positions. Do NOT place objects between the seats, this could interfere with the functioning of the pretensioner. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 113 The Personal Safety System provides the most benefit to belted occupants. The system monitors and tailors the air bag deployment based upon safety belt usage. Failure to properly wear your safety belt will increase your risk of injury. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 114 The tongue will not securely latch if you attempt to use it in any of the outboard seating position buckles. To ensure that you have used the correct buckle you should hear a snap and feel it latch. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 115 To tighten the belt, pull the loose end of the belt through the tongue until it fits snugly across the hips. Shorten and fasten the belt when not in use. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 116 If the BeltMinder warnings have expired (warnings for approximately 5 minutes) for one occupant (driver or front passenger), the other occupant can still activate the BeltMinder feature. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 117 ON... The following are reasons most often given for not wearing safety belts: (All statistics based on U.S. data) 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 118 "The people I'm with don't Set the example, teen deaths occur 4 wear belts" times more often in vehicles with TWO or MORE people. Children and younger brothers/sisters imitate behavior they see. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 119 • The parking brake is set • The gearshift is in P (Park) (automatic transmission) • The ignition switch is in the OFF position • The driver and front passenger safety belts are unbuckled 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 120 Do not use extensions to change the fit of the shoulder belt across the torso. Safety belt maintenance Inspect the safety belt systems periodically to make sure they work properly and are not damaged. Inspect the safety belts to make sure 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 121: Air Bags

  (if equipped), shoulder belt guide on seatback (if equipped), child safety seat LATCH and tether anchors, and attaching hardware, should be inspected after a collision. Ford Motor Company recommends that all safety belt assemblies in use in vehicles involved in a collision be replaced.
• Page 122 Passenger air bag ON/OFF switch. This is because the back of the infant seat is too close to the inflating air bag and the risk of a fatal injury to the infant when the air bag inflates is substantial. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 123 Do not attempt to service, repair, or modify the air bag supplemental restraint systems or its fuses. See your Ford or Lincoln Mercury dealer. The front passenger air bag is not designed to offer protection to an occupant in the center front seating position.
• Page 124 NEVER be placed in the front seats, unless the passenger air bag is turned off (if equipped with an air bag On/Off switch). See Passenger air bag ON/OFF switch. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 125 Thus, it is extremely important that occupants be properly restrained as far away from the air bag cover as possible while maintaining vehicle control. Several air bag system components get hot after inflation. Do not touch them after inflation. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 126 The front passenger sensing system is designed to meet the regulatory requirements of Federal Motor Vehicle Safety Standard (FMVSS) 208 and is designed to turn off the front passenger's frontal air bag if: 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 127 ON postion. The front passenger sensing system is designed to turn off the front passenger's frontal air bag when a rear facing child seat, a forward-facing 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 128 Always sit upright against your seatback, with your feet on the floor. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 129 The front passenger air bag is not designed to offer protection to an occupant in the center front seating position. An out of position front center occupant could affect the decision of the front passenger sensing system. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 130 Seating and Safety Restraints If it is necessary to modify an advanced front air bag system to accommodate a person with disabilities, contact the Ford Customer Relationship Center at the phone number shown in the Customer Assistance section of this Owner's Guide.
• Page 131 ON/OFF switch is in the OFF position and the ignition switch is in ON, have the passenger air bag ON/OFF switch serviced at your Ford or Lincoln-Mercury dealer immediately. In order to avoid inadvertent activation of the switch, always remove the ignition key from the passenger air bag ON/OFF switch.
• Page 132 NEVER be placed in the front seats, unless the passenger air bag is turned off (if equipped with an air bag On/Off switch). See Passenger air bag ON/OFF switch. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 133 3. Medical condition. A passenger has a medical condition which, according to his or her physician: • causes the passenger air bag to pose a special risk for the passenger; 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 134: Child Restraints

  (SRS) in this chapter for special instructions about using air bags. Important child restraint precautions You are required by law to use safety restraints for children in the U.S. and Canada. If small children (generally children who are four years old 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 135 To improve the fit of both the lap and shoulder belt on children who have outgrown child safety seats, Ford Motor Company recommends use of a belt-positioning booster. 2004 F150 (f12)
• Page 136 (top of ear level) above the top of the seat. In this case, move the backless booster to another seating position with a higher seat back and lap/shoulder belts. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 137 Never use pillows, books, or towels to boost a child. They can slide around and increase the likelihood of injury or death in a collision. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 138 27 kg (60 pounds) in a child restraint, and to provide upper torso restraint for children up to 36 kg (80 pounds) using an upper torso harness and a belt-positioning booster. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 139 Seating and Safety Restraints Ford recommends the use of a child safety seat having a top tether strap. Install the child safety seat in a seating position with LATCH and tether anchors. For more information on top tether straps and anchors, refer to Attaching safety seats with tether straps in this chapter.
• Page 140 Make sure the tongue is latched securely by pulling on it. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 141 (you should not be able to pull more belt out). If the retractor is not locked, unbuckle the belt and repeat steps two through nine. Check to make sure the child seat is properly secured before each use. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 142 The tether anchors in your vehicle may be loops of webbing above the seatback or an anchor bracket behind the seat on the rear edge of the seat cushion. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 143 The tether strap may not work properly if attached somewhere other than the correct tether anchor. • F150 Regular Cab • F150 SuperCrew and SuperCab Front seat tether strap attachment 1. Position the child safety seat on the seat cushion.
• Page 144 6. Tighten the child safety seat tether strap according to the manufacturer's instructions. If the safety seat is not anchored properly, the risk of a child being injured in a collision greatly increases. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 145 The head restraint support post will hold the child seat tightly, but the head restraint post is not strong enough to hold the child seat during a collision. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 146 See Attaching safety seats with tether straps in this chapter. Your vehicle is equipped with LATCH anchors for child seat installation at the following seating positions: • F150 Regular Cab • F150 SuperCab and SuperCrew 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 147 Also try to tug the seat forward. Check to see if the anchors hold the seat in place. If the safety seat is not anchored properly, the risk of a child being injured in a crash greatly increases. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 148 This adjustment does not work when the child seat is installed using the LATCH attachment belts instead of the vehicle safety belts. Therefore, turn the airbag OFF with the manual Airbag On/Off switch. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 149: Driving

  Do not park, idle, or drive your vehicle in dry grass or other dry ground cover. The emission system heats up the engine compartment and exhaust system, which can start a fire. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 150 Seating and Safety Restraints chapter. 2. Make sure the headlamps and vehicle accessories are off. 3. Make sure the gearshift is in P (Park). 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 151 Driving 4. Make sure the parking brake is set. BRAKE 5. Turn the key to 3 (ON) without turning the key to 4 (START). 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 152 Make sure the corresponding lights illuminate or illuminate briefly. If a light fails to illuminate, have the vehicle serviced. • If the driver's safety belt is fastened, the light may not illuminate. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 153 If the engine is idling while the vehicle is stopped for a long period of time, open the windows at least one inch (2.5 cm) or adjust the heating or air conditioning to bring in fresh air. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 154: Brakes

  ABS may be disabled and may need to be serviced. Even when the ABS is disabled, normal braking is still effective. (If your BRAKE warning lamp BRAKE illuminates with the parking brake released, have your brake system serviced immediately.) 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 155 If the steering wanders or pulls, check for: • an improperly inflated tire • uneven tire wear • loose or worn suspension components • loose or worn steering components • improper steering alignment 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 156: Transmission Operation

  This vehicle is equipped with a park/brake-shift interlock feature that prevents the gearshift lever from being moved from P (Park) when the ignition is in the ON position unless brake pedal is depressed. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 157 This vehicle is equipped with a brake-shift interlock feature that prevents the gearshift lever from being moved from P (Park) when the ignition is in the ON position unless brake pedal is depressed. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 158 N (Neutral) (two places rearward from P [Park]). 5. Start the vehicle and release the parking brake. Do not drive your vehicle until you verify that the brakelamps are working. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 159 P (Park) This position locks the transmission and prevents the rear wheels from turning. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 160 R N D 2 1 Overdrive can be deactivated by pressing the transmission control switch on the end of the gearshift lever (column-shift transmission) or on the gearshift bezel (floor-shift transmission). 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 161 • O/D (Overdrive) is automatically returned each time the key is turned off. 2 (Second) This position allows for second gear only. • Provides engine braking. • Use to start-up on slippery roads. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 162 "parking speeds". Inclement weather may also affect the function of the RSS; this may include reduced performance or a false activation. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 163 If the tailgate is down, the RSS tone may be heard intermittently or continuously. The tone may also be heard if items in the truck bed protrude rearward outside the bed. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 164 • 4X4 HI - Momentarily illuminates 4x4 HI when the engine is started. Illuminates when 4H is selected. • 4X4 LOW – Momentarily illuminates when the engine is started. Illuminates when 4L is selected. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 165 1. Bring the vehicle to a complete stop. 2. Depress the brake. 3. On vehicles equipped with an automatic transmission, place the transmission in N (Neutral); on vehicles equipped with a manual transmission, depress the clutch. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 166 4L (4WD Low) - Uses extra gearing to provide maximum power to all four wheels at reduced speeds. Intended only for off-road applications such as deep sand, steep grades or pulling heavy objects. 4L (4WD Low) 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 167 Maintain steering wheel control at all times, especially in rough terrain. Since sudden changes in terrain can result in abrupt steering wheel motion, make sure you grip the steering wheel from the outside. Do not grip the spokes. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 168 Avoid sharp turns, excessive speed and abrupt maneuvers in these vehicles. Failure to drive cautiously could result in an increased risk of loss of vehicle control, vehicle rollover, personal injury and death. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 169 • If the vehicle goes from one type of surface to another (i.e., from concrete to gravel) there will be a change in the way the vehicle responds to a maneuver (steering, acceleration or braking). Again, avoid these abrupt inputs. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 170 This is the front drivetrain coming up to speed and the automatic locking hubs engaging and is not cause for concern. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 171 After driving through mud, clean off residue stuck to rotating driveshafts and tires. Excess mud stuck on tires and rotating driveshafts causes an imbalance that could damage drive components. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 172 Ford Motor Company joins the U.S. Forest Service and the Bureau of Land Management in encouraging you to help preserve our national forest and other public and private lands by "treading lightly."...
• Page 173 Never drive with chains on the front tires of 4WD vehicles without also putting them on the rear tires. This could cause the rear to slide and swing around during braking. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 174 Ford or Lincoln/Mercury dealer. If you nevertheless decide to equip your 4WD for off-road use with tires larger than what Ford Motor Company recommends, you should not use these tires for highway driving. If you use any tire/wheel combination not recommended by Ford Motor...
• Page 175 Ford Motor Company recommends that caution be used with any vehicle equipped with a high load or device (such as ladder racks or pickup box cover).

• Page 176: Vehicle Loading

  (front and rear) – including vehicle curb weight and all payload. GAWR (Gross Axle Weight Rating) – is the maximum allowable weight that can be carried by a single axle (front or rear). These 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 177 (including all options, equipment, passengers and cargo). The GVWR is shown on the Safety Compliance Certification Label located on the driver's door or B-Pillar. The GVW must never exceed the GVWR. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 178 0.15 and 0.25 to obtain a proper king pin load range of 1,725 to 2,875 lbs. (782 to 1,304 kg) Do not exceed the GVWR or the GAWR specified on the certification label. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 179: Trailer Towing

  If your vehicle is not equipped with a heavy-duty trailer towing package, the maximum weight your vehicle can tow is limited to 5,000 lbs. (2,268 kg) 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 180 11500 (5216) 6500 (2948) 4.6L 3.73 12000 (5443) 7000 (3175) 5.4L 3.31 12000 (5443) 6800 (3084) 5.4L (w/17" 3.55 13000 (5897) 7800 (3538) tires) 5.4L (w/17" 3.73 13500 (6123) 8300 (3765) tires) 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 181 5.4L (w/17" 3.55 13000 (5897) 7600 (3447) tires) 5.4L (w/18" 3.55 12500 (5670) 7100 (3220) tires) 5.4L (w/17" 3.73 13500 (6123) 8100 (3674) tires) 5.4L (w/18" 3.73 13000 (5897) 7600 (3447) tires) 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 182 13000 (5897) 7600 (3447) tires) 5.4L (with 18" 3.55 12500 (5670) 7100 (3220) tires) 5.4L (with 17" 3.73 13500 (6123) 8100 (3674) tires) 5.4L (with 18" 3.73 13000 (5897) 7600 (3447) tires) 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 183 * Trailer tow capability is limited to 9500 lbs. (4309 kg) SuperCab 4x2 (163" wheelbase) Engine Rear axle ratio Maximum Maximum GCWR-kg trailer (lbs.) weight-kg (lbs.) 5.4L Heavy Duty 4.10 15300 (6940) 9500 (4309) 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 184 5.4L (w/17" 3.55 14000 (6350) 8300 (3765) tires) 5.4L (w/18" 3.55 13500 (6123) 7800 (3538) tires) 5.4L (w/17" 3.73 15000 (6804) 9300 (4218) tires) 5.4L (w/18" 3.73 14500 (6577) 8800 (3992) tires) 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 185 13500 (6123) 8000 (3629) tires) 5.4L (w/17" 3.73 15000 (6804) 9500 (4309)* tires) 5.4L (w/18" 3.73 14500 (6577) 9000 (4082) tires) * Trailer tow capability is limited to 9500 lbs. (4309 kg) 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 186 1. Park the unloaded vehicle on a level surface. With the ignition on and all doors closed, allow the vehicle to stand for several minutes so that it can level. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 187 The rear bumper is equipped with an integral hitch and only requires a ball with a one inch (25.4 mm) shank diameter. The bumper has a 5,000 lbs. (2,270 kg) trailer weight and 500 lbs. (227 kg) tongue weight capacity. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 188 Launching or retrieving a boat Disconnect the wiring to the trailer before backing the trailer into the water. Reconnect the wiring to the trailer after the trailer is removed from the water. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 189: Recreational Towing

  If a distance of 50 miles (80 km) or a speed of 35 mph (56 km) must be exceeded, the drive shaft will have to be removed before the vehicle is towed. Ford recommends the driveshaft be removed/installed only by a qualified technician. See your local dealer for driveshaft removal/installation. Improper removal/installation of the driveshaft can cause transmission fluid loss, damage to the driveshaft and internal transmission components.
• Page 190 Driving SNOWPLOWING Ford recommends that the F–150 used for snow removal include the Snow Plow Prep Package Option. The option is available for F–150 4x4 Regular Cab and Super Cab (not available or recommended for SuperCrew), and includes the following upgrades: •...
• Page 191 Operating the vehicle with the snowplow attached Ford recommends that the F–150 be limited to low speed, personal-use snow removal. Do not use your vehicle for snow removal until it has been driven at least 500 miles (800 km).
• Page 192 Driving Do not attempt to service, repair, or modify the air bag supplemental restraint system (SRS) or its fuses. See your Ford or Lincoln Mercury dealer. Transmission operation while plowing • Shift transfer case to 4L (4WD Low) when plowing in small areas at speeds below 5 mph (8 km/h).

• Page 193: Roadside Emergencies

  Roadside Emergencies Roadside Emergencies GETTING ROADSIDE ASSISTANCE To fully assist you should you have a vehicle concern, Ford Motor Company offers a complimentary roadside assistance program. This program is separate from the New Vehicle Limited Warranty. The service is available: •...

• Page 194: Fuel Pump Shut-Off Switch

  Roadside Emergencies Canadian customers who require roadside assistance, call 1–800–665–2006. If you need to arrange roadside assistance for yourself, Ford Motor Company will reimburse a reasonable amount. To obtain reimbursement information, U.S. Ford or Mercury vehicles customers call 1-800-241-3673; Lincoln vehicle customers call 1–800–521–4140.

• Page 195: Fuses And Relays

  Note: Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 196: Passenger Compartment Fuse Panel/Power Distribution Box

  To reinstall the fuse box cover, place the top part of the cover on the fuse panel, then push the bottom part of the cover until you hear it click shut. Gently pull on the cover to make sure it is seated properly. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 197 DVD battery power 7.5A* Keep alive memory for Powertrain Control Module (PCM) and climate control module 15A* Parklamps, BSM, Instrument panel illumination Radio (start signal) 10A* Heated mirrors, Switch indicator — Not used 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 198 10A* RH low beam headlamp 15A* Battery saver power for demand lamps 10A* LH low beam headlamp 20A* Horn relay (PCB3), Horn power 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 199 Cigar lighter, Diagnostic connector power 10A* Trailer tow left turn/stop lamps 30A** Starter solenoid 20A** Ignition switch feed 20A** ABS valves — Not used 30A** Electric trailer brakes 30A** Trailer tow battery charge 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 200 Trailer tow battery charge Full ISO relay Blower motor R201 Half ISO relay Trailer tow park lamps R202 Half ISO relay Fog lamps R203 Half ISO relay * Mini fuses ** Cartridge fuses 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 201 Roadside Emergencies Auxiliary relay box The relay box is located in the engine compartment on the left fender. • Without Daytime Running Lamp (DRL) option 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 202 Description location rating Clockspring illumination — 4x4 CCW — 4x4 CW — Daytime Running Lamps (DRL) (if equipped, otherwise not used) R201 — R202 — A/C clutch — A/C clutch diode 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 203 Ford. If the dissimilar spare tire or wheel is damaged, it should be replaced rather than repaired.
• Page 204 1. Use the ignition key to remove the lock cylinder from the access hole of the bumper to allow access to the guide tube. Assemble the jack handle as shown in the illustration. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 205 Refer to the instruction sheet (located with the jack) for detailed tire change instructions. 1. Park on a level surface, activate hazard flashers and set the parking BRAKE brake. 2. Place gearshift lever in P (Park) and turn engine OFF. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 206 If the vehicle slips off the jack, someone could be seriously injured. • Front Note: Use the frame rail as the jacking location point, NOT the control arm. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 207 (Refer to Wheel lug nut torque specifications later in this chapter for the proper lug nut torque specification): • Six lug nut wheel 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 208 5. Repeat this tightness check procedure when servicing the spare tire pressure (every six months, per Scheduled Maintenance Guide), or at any time that the spare tire is disturbed through service of other components. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 209: Jump Starting

  M14 x 2.0 * Torque specifications are for nut and bolt threads free of dirt and rust. Use only Ford recommended replacement fasteners. When a wheel is installed, always remove any corrosion, dirt or foreign materials present on the mounting surfaces of the wheel or the surface of the front disc brake hub and rotor that contacts the wheel.
• Page 210 Connecting the jumper cables 1. Connect the positive (+) jumper cable to the positive (+) terminal of the discharged battery. Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 211 A spark may cause an explosion of the gases that surround the battery. 5. Ensure that the cables are clear of fan blades, belts, moving parts of both engines, or any fuel delivery system parts. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 212 1. Remove the jumper cable from the ground metal surface. Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery. 2. Remove the jumper cable on the negative (-) connection of the booster vehicle's battery. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 213 After the disabled vehicle has been started and the jumper cables removed, allow it to idle for several minutes so the engine computer can relearn its idle conditions. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 214: Wrecker Towing

  Ford recommends your vehicle be towed with a wheel lift or flatbed. Do not tow with a slingbelt. Ford Motor Company has not approved a slingbelt towing procedure.

• Page 215: Customer Assistance

  Center at the number below. Away from home If you own a Ford or Mercury vehicle and are away from home when your vehicle needs service, or if you need more help than the dealership could provide, after following the steps described above, contact the Ford Customer Relationship Center to find an authorized dealership to help you.
• Page 216 If you own a Lincoln vehicle and are away from home when your vehicle needs service, or if you need more help than the dealership could provide, after following the steps described above, contact the Ford Customer Relationship Center to find an authorized dealership to help you.
• Page 217 5,000 participating Ford or Lincoln Mercury and Ford of Canada dealers. If you did not take advantage of the Ford Extended Service Plan at the time of purchasing your vehicle, you may still be eligible. Since this information is subject to change, please ask your dealer for complete details about Ford Extended Service Plan coverage options, or visit the Ford ESP website at www.ford-esp.com.
• Page 218 Customer Assistance The Dispute Settlement Board may not be available in all states. Ford Motor Company reserves the right to change eligibility limitations, modify procedures and/or to discontinue this service without notice and without incurring obligations per applicable state law.
• Page 219 • The name of the dealer(s) who sold or serviced the vehicle. • A brief description of your unresolved concern. • A brief summary of the action taken by the dealer(s) and Ford Motor Company. • The names (if known) of all the people you contacted at the dealership(s).
• Page 220 After a case is reviewed, the Board mails you a decision letter and a form on which to accept or reject the Board's decision. The decisions of the Board are binding on Ford (and, in some cases, on the dealer) but not on consumers who are free to pursue other remedies available to them under state or federal law.
• Page 221 If your vehicle must be serviced while you are traveling or living in Central or South America, the Caribbean, or the Middle East, contact the nearest Ford dealership. If the dealership cannot help you, write or call: FORD MOTOR COMPANY...
• Page 222 Obtaining a French owner's guide French Owner's Guides can be obtained from your dealer or by writing to Ford Motor Company of Canada, Limited, Service Publications, P.O. Box 1580, Station B, Mississauga, Ontario L4Y 4G3. IN CALIFORNIA (U.S. ONLY) California Civil Code Section 1793.2(d) requires that, if a manufacturer...

• Page 223: Reporting Safety Defects (U.s. Only)

  However, NHTSA cannot become involved in individual problems between you, your dealer, or Ford Motor Company. To contact NHTSA, you may either call the Auto Safety Hotline toll-free at 1–800–424–9393 (or 366–0123 in the Washington D.C.

• Page 224: Cleaning

  (low-gloss black) colored trim, such as grained door handles, roof racks, bumpers, side moldings, mirror housings or the windshield cowl area. The paint sealant will "gray" or stain the parts over time. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 225 • Spray Motorcraft Engine Shampoo and Degreaser (ZC-20) on all parts that require cleaning and pressure rinse clean. • Cover the highlighted areas to prevent water damage when cleaning the engine. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 226 Use only approved products to clean plastic parts. These products are available from your dealer. • For routine cleaning, use Motorcraft Detail Wash (ZC-3–A). • If tar or grease spots are present, use Motorcraft Bug and Tar Remover (ZC-42). 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 227 • Clean the interior trim areas with a damp cloth, then dry by wiping with a dry, soft, clean cloth. • Do not use household or glass cleaners as these may damage the finish. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 228 If this occurs, the leather should be cleaned immediately to avoid permanent staining. UNDERBODY Flush the complete underside of your vehicle frequently. Keep body and door drain holes free from packed dirt. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 229 Cleaning FORD, LINCOLN AND MERCURY CAR CARE PRODUCTS Your Ford, Lincoln or Mercury dealer has many quality products available to clean your vehicle and protect its finishes. These quality products have been specifically engineered to fulfill your automotive needs; they are custom designed to complement the style and appearance of your vehicle.

• Page 230: Maintenance And Specifications

  2. Turn off the engine and remove the key. 3. Block the wheels. Working with the engine on • Automatic transmission: 1. Set the parking brake and shift to P (Park). 2. Block the wheels. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 231 2. Go to the front of the vehicle and release the auxiliary latch that is located on the front bumper under the grill. 3. Lift the hood until the lift cylinders hold it open. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 232: Engine Compartment

  3. Engine oil filler cap 4. Power steering fluid reservoir 5. Engine oil dipstick 6. Brake fluid reservoir 7. Engine coolant reservoir 8. Air filter assembly 9. Windshield washer fluid reservoir 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 233 3. Air filter assembly 4. Power steering fluid reservoir 5. Engine oil dipstick 6. Brake fluid reservoir 7. Engine coolant reservoir 8. Engine oil filler cap 9. Windshield washer fluid reservoir 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 234: Engine Oil

  3. Set the parking brake and ensure the gearshift is securely latched in P (Park) (automatic transmission) or 1 (First) (manual transmission). 4. Open the hood. Protect yourself from engine heat. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 235 7. Put the indicator back in and ensure it is fully seated. Adding engine oil 1. Check the engine oil. For instructions, refer to Checking the engine oil in this chapter. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 236 Only use oils "Certified For Gasoline Engines" by the American Petroleum Institute (API). To protect your engine's warranty use Motorcraft SAE 5W-20 or an equivalent 5W-20 oil meeting Ford specification WSS-M2C153-H. SAE 5W-20 oil provides optimum fuel economy and durability performance meeting all requirements for your vehicle's engine.

• Page 237: Battery

  Maintenance and Specifications It is recommended you use the appropriate Motorcraft oil filter (or another brand meeting Ford specifications) for your engine application. BATTERY Your vehicle is equipped with a Motorcraft maintenance-free battery which normally does not require additional water during its life of service.
• Page 238 If the battery has been disconnected or a new battery has been installed, the clock and the preset radio stations must be reset once the battery is reconnected. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 239 50–50 mixture of coolant and water provides the following: • Freeze protection down to -34°F (-36°C). • Boiling protection up to 265°F (129°C). • Protection against rust and other forms of corrosion. • Enables calibrated gauges to work properly. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 240 When adding coolant, make sure it is a 50/50 mixture of engine coolant and distilled water. Add the mixture to the coolant reservoir, when the engine is cool, until the appropriate fill level is obtained. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 241 • Add Motorcraft Premium Gold Engine Coolant (yellow-colored), VC-7–A (U.S., except CA and OR), VC-7–B (CA and OR only), meeting Ford Specification WSS-M97B51–A1. Note: Use of Motorcraft Cooling System Stop Leak Pellets, VC-6, may darken the color of Motorcraft Premium Gold Engine Coolant from yellow to golden tan.
• Page 242 Recycled engine coolant Ford Motor Company does NOT recommend the use of recycled engine coolant in vehicles originally equipped with Motorcraft Premium Gold Engine Coolant since a Ford-approved recycling process is not yet available.
• Page 243 If the engine coolant supply is depleted, this feature allows the vehicle to be driven temporarily before incremental component damage is incurred. The "fail-safe" distance depends on ambient temperatures, vehicle load and terrain. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 244 2. Arrange for the vehicle to be taken to a service facility. 3. If this is not possible, wait a short period for the engine to cool. 4. Check the coolant level and replenish if low. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 245 Automotive fuels can cause serious injury or death if misused or mishandled. Gasoline may contain benzene, which is a cancer-causing agent. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 246 Care should be taken to avoid inhaling excess fumes. The flow of fuel through a fuel pump nozzle can produce static electricity, which can cause a fire if fuel is pumped into an ungrounded fuel container. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 247 The customer warranty may be void for any damage to the fuel tank or fuel system if the correct genuine Ford or Motorcraft fuel filler cap is not used. The fuel system may be under pressure. If the fuel filler cap is venting vapor or if you hear a hissing sound, wait until it stops before completely removing the fuel filler cap.
• Page 248 "Regular" unleaded gasoline because it may cause these problems to become more pronounced. If the problems persist, see your dealer or a qualified service technician. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 249 Ask your fuel supplier about gasolines that meet the World-wide Fuel Charter. Cleaner air Ford endorses the use of reformulated "cleaner-burning" gasolines to improve air quality. Running out of fuel Avoid running out of fuel because this situation may have an adverse affect on powertrain components.
• Page 250 1. Fill the fuel tank completely and record the initial odometer reading (in kilometers or miles). 2. Each time you fill the tank, record the amount of fuel added (in liters or gallons). 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 251 Unnecessary shifting of this type could result in reduced fuel economy. • Warming up a vehicle on cold mornings is not required and may reduce fuel economy. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 252 Every new vehicle should have the EPA window sticker. Contact your dealer if the window sticker is not supplied with your vehicle. The EPA window sticker should be your guide for the fuel economy comparisons with other vehicles. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 253 Guide are essential to the life and performance of your vehicle and to its emissions system. If other than Ford, Motorcraft or Ford-authorized parts are used for maintenance replacements or for service of components affecting emission control, such non-Ford parts should be equivalent to genuine Ford Motor Company parts in performance and durability.
• Page 254 Service engine soon light on. If the vehicle's powertrain system or its battery has just been serviced, the on-board diagnostics system is reset to a "not ready for I/M test" 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 255 5. If the fluid is low, add fluid in small amounts, continuously checking the level until it reaches the range between the MIN and MAX lines. Be sure to put the cap back on the reservoir. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 256 6. Install the dipstick making sure it is fully seated in the filler tube. 7. Remove the dipstick and inspect the fluid level. The fluid should be in the designated area for normal operating temperature or ambient temperature. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 257 Use of a non-approved automatic transmission fluid may cause internal transmission component damage. If necessary, add fluid in 250 ml (1/2 pint) increments through the filler tube until the level is correct. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 258 Checking and adding transfer case fluid (if equipped) 1. Clean the filler plug. 2. Remove the filler plug and inspect the fluid level. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 259 Use only fluid that meets Ford specifications. Refer to Lubricant specifications in this chapter. DRIVELINE UNIVERSAL JOINT AND SLIP YOKE Your vehicle may be equipped with universal joints that require lubrication.

• Page 260: Air Filter(S)

  This could cause filter damage and allow unmetered air to enter the engine if not properly seated. • 5.4L Engine 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 261 3. Install a new air filter element into the tray assembly. 4. Return air filter tray to original position by pressing firmly on the handle until all rearward movement stops and secure the two clamps. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 262 10 to 12 inches or limited production tires as defined in Title 49 Code of Federal Regulations Part 575.104(c)(2). U.S. Department of Transportation-Tire quality grades: The U.S. Department of Transportation requires Ford to give you the following information about tire grades exactly as the government has written it. Treadwear...
• Page 263 • Extra load: A class of P-metric or Metric tires designed to carry a heavier maximum load at 41 psi [43 psi (2.9 bar) for Metric tires]. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 264 (European Tire and Rim Technical Organization) or JATMA (Japan Tire Manufacturing Association). 2. 215: Indicates the nominal width of the tire in millimeters from sidewall edge to sidewall edge. In general, the larger the number, the wider the tire. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 265 Note: For tires with a maximum speed capability over 149 mph (240 km/h), tire manufacturers sometimes use the letters ZR. For those with a maximum speed capability over 186 mph (299 km/h), tire manufacturers always use the letters ZR. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 266 This pressure is normally higher than the manufacturer's recommended cold inflation pressure which can be found on either the tire label or certification label 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 267 4. Maximum Load Single lbs. (kg) at psi (kPa) cold: Indicates the maximum load and tire pressure when the tire is used as a single; defined as two tires (total) on the rear axle. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 268 Use a tire gauge to check the tire inflation pressure, including the spare, at least monthly and before long trips. You are strongly urged to buy a reliable tire pressure gauge, as automatic service station gauges may be 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 269 Maintenance and Specifications inaccurate. Ford recommends the use of a digital or dial type tire pressure gauge rather than a stick type tire pressure gauge. Use the recommended cold inflation pressure for optimum tire performance and wear. Under-inflation or over-inflation may cause uneven treadwear patterns.
• Page 270 If your vehicle seems to pull to one side when you're driving, the wheels may be out of alignment. Have a qualified technician at a Ford or Lincoln/Mercury dealer check the wheel alignment periodically.
• Page 271 (front tires at top of diagram) • Rear Wheel Drive (RWD) vehicles/Four Wheel Drive (4WD) vehicles (front tires at top of diagram) Sometimes irregular tire wear can be corrected by rotating the tires. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 272 Maintenance and Specifications Note: If your tires show uneven wear ask a qualified technician at a Ford or Lincoln/Mercury dealership to check for and correct any wheel misalignment, tire imbalance or mechanical problem involved before tire rotation. Note: Your vehicle may be equipped with a dissimilar spare tire/wheel. A dissimilar spare tire/wheel is defined as a spare tire and/or wheel that is different in brand, size or appearance from the road tires and wheels.
• Page 273 Only use replacement tires and wheels that are the same size and type (such as P-metric versus LT-metric or all-season versus all-terrain) as those originally provided by Ford. Use of any tire or wheel not recommended by Ford can affect the safety and performance of your vehicle, which could result in an increased risk of loss of vehicle control, vehicle rollover, personal injury and death.
• Page 274 • Remove the tire chains when they are no longer needed. Do not use tire chains on dry roads. • The suspension insulation and bumpers will help prevent vehicle damage. Do not remove these components from your vehicle when using snow tires and chains. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 275: Part Numbers

  If the label shows "REP" it uses oil filter number FL-820-S. If the label shows "Ford Windsor" it uses oil filter number FL-400-S. The correct oil filter must be used as previously described.

• Page 276: Refill Capacities

  Engine oil Motorcraft 4.6L engine 5.7L (6.0 quarts) (includes SAE 5W-20 filter Premium change) Synthetic Blend Motor Oil (US) Motorcraft 5.4L engine 6.6L (7.0 quarts) SAE 5W-20 Super Premium Motor Oil (Canada) 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 277 MERCON Transmission Motorcraft 4R70/75 E-W 13.2L (13.9 quarts) fluid MERCON V Front axle Motorcraft 4x4 vehicles 2.0L (3.7 pints) SAE 75W-90 Fuel Efficient High Performance Synthetic Rear Axle Lubricant 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 278 Some transmission fluids may be labeled as dual usage, such as MERCON and MERCON V. These dual usage fluids are not to be used in an automatic transmission that requires use of the MERCON type 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 279 4 oz. (118 ml) of FEHP Friction Modifier XL-7 or equivalent. Use of synthetic or synthetic blend motor oil is not mandatory. Engine oil need only meet the requirements of Ford specification WSS-M2C153–H and the API Certification mark. 2004 F150 (f12)

• Page 280: Lubricant Specifications

  API Synthetic Blend CXO-5W20– Certification Motor Oil LSP12 (Canada) Mark Engine oil Motorcraft SAE 5W-20 Super Premium Motor Oil (Canada) Multi-Purpose XG-4 or XL-5 ESR-M1C159-A Seat tracks Grease or ESB-M1C93-B 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 281 Check the container to verify the fluid being added is of the correct type. Refer to your Scheduled Maintenance Guide to determine the correct service interval. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 282 Required fuel 87 octane 87 octane Firing order 1-3-7-2-6-5-4-8 1-3-7-2-6-5-4-8 Ignition system Coil on plug Coil on plug Compression ratio 9.37:1 9.85:1 The 5.4L 3V spark plug gap CANNOT be adjusted. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 283 144.0 (3668) / – 4x2/4x4 126.0 (3203) 126.0 (3203) 145.0 (3675) (5) Track - 67.0 (1701) 67.0 (1701) 67.0 (1701) Front (5) Track - 67.0 (1701) 67.0 (1701) 67.0 (1701) Rear 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 284 163.0 (4140) / – 4x2/4x4 133.0 (3371) 145.0 (3675) 163.0 (4148) (5) Track - 67.0 (1701) 67.0 (1701) 67.0 (1701) Front (5) Track - 67.0 (1701) 67.0 (1701) 67.0 (1701) Rear 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 285 Maintenance and Specifications Super Crew Vehicle dimensions Styleside 5.5' box - inches (mm) (1) Overall length 224.0 (5689) (2) Overall width 78.9 (2005) (3) Overall height – 4x2/4x4 73.5 (1867) / 75.5 (1918) 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 286 Super Crew Vehicle dimensions Styleside 5.5' box - inches (mm) (4) Wheelbase – 4x2/4x4 138.0 (3515) / 139.0 (3523) (5) Track - Front 67.0 (1701) (5) Track - Rear 67.0 (1701) 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 287 Certification label may be located. The Certification label is located on the structure by the trailing edge of the driver's door or the edge of the driver's door. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 288 6. Model year 7. Assembly plant 8. Production sequence number Engine number The engine number (the last eight numbers of the vehicle identification number) is stamped on the engine block and transmission. 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 289 Manual 5–speed overdrive (Dana ZF) Manual 6–speed ZF Automatic transmission Automatic 4–speed overdrive (CD4E) Automatic 4–speed overdrive (4R70W) Automatic 4–speed overdrive (4R44E) Automatic 4–speed overdrive (4R100) Automatic 5–speed overdrive (5R55E) Electric One speed electric 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 290 4–speed overdrive (AX4S) 4–speed overdrive (4F20E) 4–speed overdrive (4F50N) 4–speed overdrive (CD4E) Rear wheel drive manual transaxle 5–speed (Mazda M5) Rear wheel drive automatic transmission 4–speed overdrive (4R70W) 5–speed overdrive (5R55N) 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

• Page 291: Accessories

  In addition, each accessory is made from high quality materials and meets or exceeds Ford's rigorous engineering and safety specifications. Ford Motor Company will repair or...
• Page 292 Rear seat entertainment systems Toolboxes Towing mirrors TracRac and accessories Trailer hitches, wiring harnesses and accessories Peace of mind Airbag anti-theft locks First aid and highway safety kits Full vehicle covers 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 293 • Electrical or electronic accessories or components that are non-Genuine Ford Accessories added to the vehicle by the dealer or the owner may adversely affect battery performance and durability. 2004 F150 (f12)

• Page 294: Index

  ..280, 282 engine compartment ....225 refill capacities ......276 instrument panel ....227 traction lok ......156 interior ........228 interior trim ......227 plastic parts ......226 safety belts ......228 Battery ........237 washing ........224 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 295 Electronic message center ..71 Emergencies, roadside Cruise control (see Speed control) ....63 jump-starting ......209 Customer Assistance ....193 Emergency Flashers ....194 Ford accessories for your Emission control system ..253 vehicle ........229 Engine ........282–283 Ford Extended Service cleaning ........225 Plan ..........217 coolant ........239 Getting assistance outside fail-safe coolant ......243...
• Page 296 ...248, 282–283 Homelink wireless control quality ........248 system ..........67 running out of fuel ....249 Hood ..........231 safety information relating to automotive fuels ....245 Ignition .......149, 282–283 Fuel pump shut-off switch ..194 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 297 .....46–47 replacing bulbs ....48–52 Parking brake ......155 Parts (see Motorcraft parts) ..275 Lane change indicator (see Turn signal) ......46 Passenger Occupant Classification Sensor ....106 Lights, warning and indicator ..10 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 298 ......209 Safety defects, reporting ..223 Steering wheel Safety controls ........65 restraints ...104, 108–112, 114 tilting .........54 extension assembly ....120 for adults ......109–112 for children .....134–135 lap belt ........114 Tailgate ........81 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)
• Page 299 Transfer case power down back window ..60 fluid checking ......258 Windshield washer fluid and Transmission ......156 wipers ..........53 brake-shift interlock checking and adding fluid ..234 (BSI) ........156–157 replacing wiper blades .....53 2004 F150 (f12) Owners Guide (post-2002-fmt) USA English (fus)

Posted by: troytroyzelenskie0267075.blogspot.com

Source: https://www.manualslib.com/manual/624774/Ford-F150.html

Share :